Replacement
Hint:
Collect the coolant in a container and dispose of it according to the regulations in your area.
Caution:
Do not remove the radiator reservoir cap while the engine and radiator are still hot.
Pressurized, hot engine coolant and steam may be released and cause serious burns.
Torque: 12.7 N*m (130 kgf*cm, 10 ft.*Lbf)
Hint:
The b line is the lower edge of the inner wall of the filler neck.
Standard capacity: 6.8 Liters (7.2 Us qts, 5.9 Imp. Qts)
Hint:
Toyota vehicles are filled with toyota sllc at the factory. In order to avoid damage to the engine cooling system and other technical problems, only use toyota sllc or similar high quality ethylene glycol based non-silicate, non-amine, non-nitrite, non-borate coolant with long-life hybrid organic acid technology (coolant with long-life hybrid organic acid technology consists of a combination of low phosphates and organic acids).
Notice:
Never use water as a substitute for engine coolant.
Notice:
Caution:
When pressing the radiator hoses:
If the coolant level is below the low line, repeat all of the procedures above.
If the coolant level is above the full line, drain coolant so that the coolant level is between the full and low line.
Check for open circuit
For an open circuit in the wire harness in fig. 1,
Check the resistance or voltage, as described below.
Check the resistance.
Disconnect connectors a and c, and measure
the resistance between them.
Standard resistance (fig. 2)
Hint:
Measure the resistance while lightly s ...
Disassembly
Hint:
When removing the ornament plate and emblem, heat the
radiator grille, ornament plate and emblem using a heat light.
Standard heating temperature
Notice:
Do not heat the radiator grille, ornament plate and
emblem excessively.
Remove hood to radiator grille seal
Remove th ...
Test mode procedure
Hint:
By switching the skid control ecu from normal mode to
test mode, abnormality detection sensitivity is enhanced
and troubleshooting can be conducted efficiently.
Perform a sensor check in test mode after the speed
sensor or sensor rotor has been repaired or replaced.
If the igniti ...