Toyota RAV4 Service Manual: Disassembly
- Remove sliding roof drive gear subassembly
- Remove the claw and room light bracket.
- Remove the 2 bolts and drive gear.
- Remove sliding roof drain hose joint lh
- Remove the screw and joint.
- Remove sliding roof drain hose joint rh
Hint:
Use the same procedures described for the lh side.
- Remove sunshade trim sub-assembly
- Slide and remove the sunshade trim sub-assembly.
- Remove sliding roof drive cable
Notice:
Do not disassemble the sliding roof drive cable subassembly except when replacing it.
- Remove the 2 screws and 2 sliding roof side stoppers.
- Using a screwdriver, detach the 2 claws. Then slide the drip channel rearward to remove it.
Hint:
Tape the screwdriver tip before use.
- Using a screwdriver, slide the drive cables backward and remove them.
Hint:
- Tape the screwdriver tip before use.
Removal (2006/01- )
Disconnect cable from negative battery
terminal
Caution:
Wait at least 90 seconds after disconnecting the
cable from the negative (-) battery terminal to
prevent airbag and seat belt preten ...
Reassembly
Install sliding roof drive cable
Using a screwdriver, slide the sliding roof drive
cable sub-assemblies in the direction indicated by
the arrow in the illustration to install them.
...
Other materials:
For vehicles equipped with mobile communication systems
Install the antenna as far away from the ecu and
sensors of the vehicle electronic systems as
possible.
Install an antenna feeder at least 20 cm (7.87 In.)
Away from the ecu and sensors of the vehicle
electronic systems. For details about ecu and
sensor locations, refer to the sec ...
Removal
Hint:
Use the same procedures for the rh side and lh side.
The procedures listed below are for the lh side.
Disconnect cable from negative battery terminal
Notice:
Wait at least 90 seconds after disconnecting the
cable from the negative (-) battery terminal to
prevent airbag and se ...
Vehicle load limits
Vehicle load limits include total load capacity, seating capacity,
twr (trailer weight rating) and cargo capacity.
Total load capacity (vehicle capacity weight)
Total load capacity means the combined weight of occupants, cargo
and luggage.
Seating capacity: 5 occupants (front 2, rear 3)
Seatin ...
