Toyota RAV4 Service Manual: Disassembly
Hint:
When removing the ornament plate and emblem, heat the radiator grille, ornament plate and emblem using a heat light.
Standard heating temperature
Notice:
Do not heat the emblem base and emblem excessively.
- Remove hood to radiator grille seal
- Remove the double-side tape.
- Detach the 7 clips and remove the hood to radiator grille seal.
- Remove radiator grille ornament plate (for separate type)
- Remove the 12 screws and ornament plate.
- Remove radiator grille emblem
- Using a screwdriver, detach the 4 claws and remove the emblem from the radiator grille.
Hint:
Tape the screwdriver tip before use.
Notice:
- If reusing the emblem, take care not to damage the emblem.
- Be careful not to damage the emblem base.
Radiator grille
Components
Removal
Remove radiator grille (see page et-6)
Remove no. 1 Radiator grille lower (see
page et-7)
Remove no. 2 Radiator grille lower (see
page et-7)
...
Reassembly
Hint:
When installing the ornament plate and emblem, heat the
radiator grille, ornament plate and emblem using a heat light.
Standard heating temperature
Notice:
Do not heat the emblem base and ...
Other materials:
Open in stop light switch circuit
Description
The skid control ecu detects the brake operating conditions through a signal
transmitted by the stop light
switch. The skid control ecu incorporates an open circuit detection circuit.
This dtc is set under either of
the following conditions:
An open is detected in the stop lig ...
Problem symptoms table (2006/01- )
Hint:
Use the table below to help determine the cause of the
problem symptom. The potential causes of the symptoms
are listed in order of probability in the "suspected area"
column of the table. Check each symptom by checking the
suspected areas in the order they are listed. R ...
Customer problem analysis
Hint:
In troubleshooting, confirm that the problem symptoms
have been accurately identified. Preconceptions should be
discarded in order to make an accurate judgment. To
clearly understand what the problem symptoms are, it is
extremely important to ask the customer about the
problem an ...
