Toyota RAV4 Service Manual: Front axle hub bolt
Components
Replacement
Hint
- Use the same procedures for the rh side and lh side.
- The procedures listed below are the lh side.
- Remove front wheel
- Remove front disc brake cylinder assembly lh (see page br-40)
- Remove front disc (see page br-42)
- Remove front axle hub bolt
- Using sst, remove the hub bolt that needs to be replaced.
Sst 09650-17011
- Install front axle hub bolt
- Insert a new hub bolt into the bolt hole. Set a plate washer and nut on the hub bolt end.
- Using a brass bar or equivalent to hold the front axle, install the hub bolt by tightening the nut. Then remove the nut and plate washer.
- Install front disc (see page br-43)
- Install front disc brake cylinder assembly lh (see page br-46)
- Install front wheel torque: 103 n*m (1,050 kgf*cm, 76 ft.*Lbf)
Axle system
Problem symptoms table
Hint:
Use the table below to help determine the cause of the
problem symptom. The potential causes of the symptoms are
listed in order of probability in the "suspected ...
Front axle hub
Components (2005/11-2006/01)
Components (2006/01- )
On-vehicle inspection
Check front axle hub bearing
Remove the front wheel.
Disconnect the front disc brake cylinder (see p ...
Other materials:
Removal
Disconnect cable from negative battery
terminal
Caution:
Wait at least 90 seconds after disconnecting the
cable from the negative (-) battery terminal to
prevent airbag and seat belt pretensioner activation.
Remove accelerator pedal rod
Disconnect the accelerator pedal position ...
Precaution
Caution:
Replace the faulty parts of the seat belt systems (outer
belt, inner belt, bolts, nuts, adjustable shoulder anchor,
tether anchor hardware and other related parts). When
inspecting a vehicle that was in a collision, be sure to
check all of the seat belt systems regardless of whethe ...
Installation
Install rear differential support
Install the differential support to the differential
carrier with the 4 bolts.
Torque: 98 n*m (999 kgf*cm, 72 ft.*Lbf)
Install rear differential no. 1 And no. 2 Support
Install the differential no. 1 And no. 2 Supports with
the 4 bo ...
