Toyota RAV4 Service Manual: General maintenance (2006/01- )
- Inspect drive belt (see page em-7)
- Replace spark plugs (see page ig-7)
- Replace air cleaner filter
- Remove the air filter.
- Visually check that the air filter is not excessively damaged or oily.
- Replace the air filter with a new one, if necessary.
- Replace engine oil and oil filter (see page lu-1)
- Replace engine coolant (see page co-1)
- Inspect gasket in fuel tank cap (see page ec-28)
- Inspect fuel lines and connections, fuel tank vapor vent system hoses
- Visually check the fuel lines for cracks, leakage, loose connections, deformation.
- Inspect exhaust pipes and mountings
- Visually check the pipes, hangers and connections for severe corrosion, leaks or damage.
General maintenance (2005/11-2006/01)
Inspect drive belt (see page em-6)
Replace spark plugs (see page ig-7)
Replace air cleaner filter
Remove the air filter.
Visually check that the air filter is not excessively
damaged ...
Brake
General maintenance
Inspect brake lines and hoses
Hint:
Work in a well-lighted area. Turn the front wheels fully to
the right or left before beginning the inspection.
Using a mirror, ...
Other materials:
Removal
Disconnect cable from negative battery
terminal
Caution:
Wait at least 90 seconds after disconnecting the
cable from the negative (-) battery terminal to
prevent airbag and seat belt pretensioner activation.
Disconnect cable from positive battery
terminal
Remove battery clamp
...
Installation
Install engine coolant temperature
sensor
Install a new gasket onto the sensor.
Using sst, install the sensor.
Sst 09817-33190
torque: 19.6 N*m (200 kgf*cm, 14 ft.*Lbf)
Connect the sensor connector.
Install air cleaner case (see page es-431)
Install air cleaner cap ( ...
Rear door courtesy switch
Components
Removal
Hint:
Use the same procedures for the rh and lh sides.
The procedures listed below are for the lh side.
Disconnect cable from negative battery
terminal
Caution:
Wait at least 90 seconds after disconnecting the
cable from the negative (-) battery terminal t ...
