Toyota RAV4 manuals

Toyota RAV4 Service Manual: Transmission oil cooler

Components

Toyota RAV4. Transmission oil cooler


Removal

  1. Remove transmission oil cooler

Toyota RAV4. Remove transmission oil cooler


  1. *1: Disconnect the no. 3 Water by-pass hose from the transmission oil cooler.
  2. *2: Disconnect the no. 4 Water by-pass hose from the transmission oil cooler.
  3. *3: Disconnect the no. 1 Oil cooler inlet hose from the transmission oil cooler.
  4. *4: Disconnect the no. 1 Oil cooler outlet hose from the transmission oil cooler.
  5. Remove the 3 bolts and oil cooler from the bracket.

Toyota RAV4. Remove transmission oil cooler


Installation

  1. Install transmission oil cooler

Toyota RAV4. Install transmission oil cooler


  1. Install the oil cooler to the bracket with the 3 bolts.

Torque: 12 n*m (122 kgf*cm, 9 ft.*Lbf)

Toyota RAV4. Install transmission oil cooler


Toyota RAV4. Install transmission oil cooler


  1. *1: Connect the no. 1 Oil cooler outlet hose to the transmission.
  2. *2: Connect the no. 1 Oil cooler inlet hose to the transmission.
  3. *3: Connect the no. 3 Water by-pass hose to the transmission.
  4. *4: Connect the no. 4 Water by-pass hose to the transmission.
  1. Add automatic transaxle fluid

  2. Inspect automatic transaxle fluid

  1. Inspect the automatic transaxle fluid (see page ax- 102).
  1. Add coolant

  1. Add the coolant (see page co-6).
Shift lock system
Parts location System diagram On-vehicle inspection Check shift lock operation Move the shift lever to p. Turn the ignition switch off. Check that the shift lever cannot be mov ...

Transmission control cable assembly
Replacement Remove rear console box sub-assembly Remove the console box (see page ip-20). Disconnect cable from negative battery terminal Caution: Wait at least 90 seconds after ...

Other materials:

Precaution
Notice: Take extra care to replace each part properly. Improper installation or repair could affect the performance of the brake system and cause a driving hazard. It is very important to keep the brake system parts and the work area clean when repairing the brake system. If the vehicl ...

Removal (2005/11-2006/01)
Remove front wheel Drain automatic transaxle fluid Drain the automatic transaxle fluid for u140f (see page ax-147). Drain the automatic transaxle fluid for u241e (see page ax-146). Remove front axle hub nut (see page ah-6) Disconnect front speed sensor lh (see page bc-191) ...

Parking brake
Sets the parking brake Fully pull the parking brake while depressing the brake pedal. Releases the parking brake Slightly raise the lever and lower it completely while pressing the button. Usage in winter time Notice Before driving Fully release the parking brake. Driving t ...

В© 2011-2024 Copyright www.trav4.net